Dynamic forces and processes in the rails under impact interaction of wheels with defects
https://doi.org/10.21780/2223-9731-2016-75-6-354-364
Abstract
The paper presents the main results of comprehensive experimental studies on the determination of regularities of dynamic processes and actual values of the forces of interaction of wheels with defects on rolling surface and rails on the modern designs of the track, carried out at the experimental section of railway track. It was determined experimentally that: dynamic processes of interaction of wheels with defects such as flats, weld-on, uneven rolling have specific shape and phase marked by the geometrical shape of defects; dependencies on impact forces to the flat-type defects were approximated by a polynomial function with the highest levels of forces in the speed range of 50 - 70 km/h. For defects such as weld-on or uneven rolling marked by impact forces with increasing speed; all the above types of defects are marked by considerable variation of levels of impact forces for the same modes of running (speed, direction), which is connected with meandering nature of the movement of wheelset, determining differences in the interaction of wheel and rail; dynamic impact loads initiate pulsed total deflection of rail in the vertical direction and the horizontal transverse motion. Values of total vertical deflection reach 8 - 9 mm for the values of impact forces of 400 - 450 kN that is 3.5 - 4 times more than the quasi-static motion of rolling stock; dynamic impact impulse excites damped oscillatory processes in vertical and horizontal directions with decay time 0.1 - 0.12 seconds. The levels of vertical acceleration in the rails with impact forces of 400 - 450 kN reached 191 - 258 m/s. The spectrums of vertical oscillations dominated oscillations with a frequency of 6.4, 50 - 60, 90 - 110 Hz. The presence of high-frequency components is connected to the excitation of vertical vibrations of the rail-sleeper network. In the process of impact interaction rail oscillations with frequencies of 25, 75 - 80 Hz also developed laterally.
About the Authors
O. G. Krasnov
Joint Stock Company “Research Design and Technological Institute of Rolling Stock” (JSC “VNIKTI”)
Russian Federation
Russian Federation
O. K. Bogdanov
Joint Stock Company “Research Design and Technological Institute of Rolling Stock” (JSC “VNIKTI”)
Russian Federation
Russian Federation
M. G. Akashev
Joint Stock Company “Research Design and Technological Institute of Rolling Stock” (JSC “VNIKTI”)
Russian Federation
Russian Federation
References
1. Petrov N. P. Napryazheniya v rel’sakh ot vertikal’nykh davleniy katyashchikhsya koles. Vliyanie skorosti i nepravil’nogo vida koles [Stresses in the rails from vertical pressure of rolling wheels. The impact of speed and the wrong shape of wheels]. Zapiski Russkogo tekhnicheskogo obshchestva [Notes of the Russian Technical Society]. Saint-Petersburg, 1907, 120 p.
2. Kholodetskiy A. A. K voprosu o vliyanii skorosti i nepravil’nogo vida kolesa na dinamicheskie progiby rel’sov [On the effect of the speed and the wrong kind of wheels on the dynamic deflections of rails]. Moscow, 1915, 93 p.
3. Mityushin N. T. Vliyanie vyboin na dinamicheskie napryazheniya v rel’sakh [Effect of corrugations on the dynamic stresses in the rails]. Trudy MIIT [Proceedings of MIIT]. Moscow, Transzheldorizdat Publ., 1932, no. 32, pp. 35 – 51.
4. Krachkovskiy V. P. Dinamicheskoe vozdeystvie nagruzki na zheleznodorozhnyy put’ [Dynamic impact of load on the railway track]. Raschety zheleznodorozhnogo puti. Trudy MIIT [Calculations of railway track. Proceedings of MIIT]. Moscow, Transzheldorizdat Publ., 1937, no. 54, pp. 42 – 217.
5. Shakhunyants G. M. Raschety verkhnego stroeniya puti [Calculations on railway track superstructure]. Moscow, Transzheldorizdat Publ., 1959, 264 p.
6. Mishchenko K. N. Ponyatie ob udarnom vozdeystvii [The concept of impact action], G. M. Shakhunyats. Ustroystvo zheleznodorozhnogo puti [Structure of railway track], Vol. III, Chapter V, Par. 19. Moscow, Transzheldorizdat Publ., 1944, pp. 411 – 421.
7. Popov A. A. K voprosu o dinamicheskom vozdeystvii kolesa na rel’s pri prokhozhdenii nerovnostey puti [On the question of dynamic effects of the wheels on the rails when passing track irregularities]. Trudy TsNII MPS [Proceedings of TsNII MPS]. Moscow, Transzheldorizdat Publ., 1949, no. 33, pp. 155 – 186.
8. Korolyov K. P. Vpisyvanie parovozov v krivye uchastki puti [Performance of steam locomotive in curves sections of track]. Trudy TsNII MPS [Proceedings of TsNII MPS]. Moscow, Transzheldorizdat Publ., 1950, no. 37, 224 p.
9. Danilov V. N. Raschet rel’sovoy niti v zone styka [Calculation of the rail line in the junction area]. Trudy VNIIZhT [Proceedings of VNIIZhT]. Moscow, Transzheldorizdat Publ., 1952, no. 70, 113 p.
10. Verigo M. F. Vertikal’nye sily, deystvuyushchie na put’ pri prokhozhdenii podvizhnogo sostava [Vertical forces acting on the track when rolling stock is passing]. Vzaimodeystvie puti i podvizhnogo sostava i voprosy raschetov puti. Trudy Vsesoyuzn. nauch. issled. in-ta zh. d. transporta [Interaction of track and rolling stock and issues of track calculations. Proc. of the All-Union Scientific Research Institute of Railway transport]. Moscow, Transport Publ., 1955, no. 97, pp. 25 – 288.
11. Verigo M. F., Kogan A. Ya. K voprosu o protsessakh vzaimodeystviya neobressorennykh mass i puti [On the question of the processes of interaction of unsprung masses]. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 1969, no. 6, pp. 22 – 25.
12. Verigo M. F., Kogan A. Ya. Vzaimodeystvie puti i podvizhnogo sostava [Interaction of track and rolling stock]. Moscow, Transport Publ., 1986, 560 p.
13. Timoshenko S. P. O dinamicheskikh napryazheniyakh v rel’sakh [About the dynamic stresses in the rails]. Vestnik inzhenera,1915, no. 4, pp. 143 – 152.
14. Kogan A. Ya. Dinamika puti i ego vzaimodeystvie s podvizhnym sostavom [Dynamics of the railway track and its interaction with rolling stock]. Moscow, Transport Publ., 1997, 326 p.
15. Kogan A. Ya., Peych Yu. L. Raschet nestatsionarnogo napryazhenno-deformirovannogo sostoyaniya elementov konstruktsii puti v zone styka rel’sov [Calculation of non-stationary stressstrain state of structural elements of railway track in the junction area of the rails]. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2002, no. 2, pp. 31 – 39.
16. Kogan A. Ya., Nikitin D. A., Poleshchuk I. V. Kolebaniya puti pri vysokikh skorostyakh dvizheniya ekipazhey i udarnom vzaimodeystvii kolesa i rel’sa [Oscillations of track at high speeds of carriages and impact interaction of wheel and rail]. Moscow, Intext Publ., 2007, 168 p.
17. Kogan A. Ya. Vozdeystvie na put’ poezdov, imeyushchikh v svoem sostave vagony s polzunami na kolesnykh parakh [Impact on the railway track of trains, having in its composition carriages flats on wheelsets]. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2014, no. 3, pp. 3 – 7.
18. Kovalev R., Lysikov N., Mikheev G., Pogorelov D., Simonov V., Yazykov V., Zakharov S., Zharov I., Goryacheva I., Soshenkov S., Torskaya E., Freight car models and their computer-aided dynamic analysis. Multibody System Dynamics, 2010, Vol. 22 (4), pp. 399 – 423.
19. Kudryavtsev N. N. Issledovanie dinamiki neobressorennykh mass vagonov [Research of dynamics of unsprung masses of cars]. Trudy Vsesoyuzn. nauch. issled. inst, zh. d. transporta [Proc. of the All-Union Scientific Research Institute of Railway transport]. Moscow, Transport Publ., 1965, no. 97, 168 p.
Review
For citations:
Krasnov O.G., Bogdanov O.K., Akashev M.G. Dynamic forces and processes in the rails under impact interaction of wheels with defects. RUSSIAN RAILWAY SCIENCE JOURNAL. 2016;75(6):354-364. (In Russ.) https://doi.org/10.21780/2223-9731-2016-75-6-354-364
Views:
1005
.jpg)
Email this article 