Determining the force of interaction in a wheel - rail system based on measuring stresses in rails neck
https://doi.org/10.21780/2223-9731-2017-76-6-354-361
Abstract
When implementing new or modernized rolling the train in most cases is in the range of 0.9-0.95 and varies de-stock, one of the main problems is the provision of both traffic pending on the position in the track of a group of wheelsets. The safety, and the strength of the carriage and the ways that are de-correlation level of the frame force measured in the carriage and termined by forces in the wheel - rail system. It is almost impossible the sum of lateral forces by its average values is 0.98. A practical to directly measure the forces of interaction between the crew and method for determining the forces of interaction with respect to the track. Their determination can be carried out by measuring the stresses in the neck of a rail was proposed by Schlumpf. It involves stresses in rails, the interdependencies of which with forces are of determining the difference of the moments in the two cross sections a probabilistic nature. Correlation of the strength and stresses for of the rail neck with the angular moment of resistance to bending being equal. In this case, when the scale factors are equal to the difference of the moments, the lateral force is determined. The calculations were made by subtracting electrical signals (four strain gauges were included in the shoulders of the Wheatstone bridge), and a separate bridge was used to determine the vertical load. Errors in determining the lateral force are due to inaccurate location of the sensor sticking, the difference in the dimensions of the rail neck and the displacement of the point of application of the vertical load on the rail head. However, since the maximum forces are realized when the wheel climbs on the rail, this displacement varies insignificantly. Therefore, the results obtained can be used in conducting certification tests. The method of digital processing of data on stresses at three points of the rail neck requires for its implementation more strain gages, but the accuracy of its results is much higher, since it depends only on the errors of preliminary calibration of the cross sections. The error in calculating the forces does not exceed 4%, which shows the expediency of using the three-point method in determining the interaction forces to establish the conditions of circulation.
About the Authors
Yu. S. Romen
Joint Stock Company “Railway Research Institute” (JSC “VNIIZhT”)
Russian Federation
Russian Federation
O. A. Suslov
Joint Stock Company “Railway Research Institute” (JSC “VNIIZhT”)
Russian Federation
Russian Federation
A. A. Balyaeva
Joint Stock Company “Railway Research Institute” (JSC “VNIIZhT”)
Russian Federation
Russian Federation
References
1. Verigo M. F., Kogan A. Ya. Vzaimodeystvie puti i podvizhnogo sostava [Interaction of the track and rolling stock]. Moscow, Transport Publ., 1986, 559 p.
2. Esveld C. Modern Railway Track. 2-nd edition. MRT Proctions, 2001, 740 p.
3. Frishman M. A. Vzaimodeystvie puti i podvizhnogo sostava [Interaction of the track and rolling stock]. Moscow, Transzheldorizdat, 1956, 280 p.
4. Prigge W. Die Beanspruchung einer einfachgewellten Eisenbahnradscheibe. Ermittlung der Spannungen mit dem Dehnungsmesstreifenverfahren. Glasers Annalen, 1959, Vol. 83, no. 3, pp. 69 – 73.
5. Prigge W. Die Beanspruchung einer einfachgewellten Eisenbahnradscheibe. Ermittlung der Spannungen durch spannungsoptische Verfahren. Glasers Annalen, 1959, Vol. 83, no. 4, pp. 132 – 136.
6. Оlson Р., Johnsson S. Seitenkrafte zwischen Rad und Schiene, eine experimentele Untersuchung. Glasers Annalen, 1959, Heft 5, pp. 153 – 161.
7. Romen Yu. S. Dinamika zheleznodorozhnogo ekipazha v rel'sovoy kolee. Metody rascheta i ispytaniy [Dynamics of the railway carriage in the rail track. Methods of calculation and testing]. Moscow, VMG-Print Publ., 2014, 210 p.
8. Romen Yu. S., Tikhov M. S. Ob"em informatsii dlya ustanovleniya dopustimykh skorostey dvizheniya po rezul'tatam kompleksnykh ispytaniy [The volume of information for establishing the permissible speeds of movement based on the results of complex tests]. Podvizhnoy sostav XXI veka: idei, trebovaniya, proekty. Sb. nauch. tr. [Rolling stock of the XXI century: ideas, requirements, projects. Coll. of scientific papers]. St. Petersburg, PGUPS Publ., 2007, pp. 87 – 94.
9. Korolev K. P. Vpisyvanie parovozov v krivye uchastki puti [Entering steam locomotives into curved path sections]. Trudy Ts- NII MPS [Proc. of the Central Research Institute of the Ministry of Railways]. Moscow, Transzheldorizdat Publ., 1950, no. 37, 224 p.
10. Tikhov M. S. Opredelenie usloviy obrashcheniya podvizhnogo sostava s ispol'zovaniem korrelyatsii v pokazatelyakh vzaimodeystviya ekipazha i puti. Kand. tekhn. nauk avtoref. [Determination of the conditions of circulation of rolling stock using correlation in the parameters of the interaction between the crew and the track. Cand. tech. sci. synopsis]. Moscow, 2007, 24 p.
11. Timoshenko S. P. Metod issledovaniy staticheskikh i dinamicheskikh napryazheniy v rel'se [Method for studying static and dynamic stresses in the rail]. Staticheskie i dinamicheskie problemy teorii uprugosti [Static and dynamic problems of the theory of elasticity]. Kiev, Naukova dumka Publ., 1975, 563 p.
12. Shafranovskiy A. K. Nepreryvnaya registratsiya vertikal'nykh i bokovykh sil vzaimodeystviya kolesa i rel'sa [Continuous recording of vertical and lateral forces of wheel and rail interaction]. Trudy TsNII MPS [Proc. of the Central Research Institute of the Ministry of Railways]. Moscow, Transzheldorizdat Publ., 1965, no. 308, 96 p.
13. Shafranovskiy A. K. Izmerenie i nepreryvnaya registratsiya sil vzaimodeystviya kolesnykh par lokomotivov s rel'sami [Measurement and continuous registration of forces of interaction of wheelsets of locomotives with rails]. Trudy VNIIZhT [Proc. of the JSC “VNIIZhT”]. Moscow, Transport Publ., 1969, no. 389, 120 p.
14. Brzhezovskiy A. M. Metody eksperimental'noy otsenki bokovykh sil (obzor) [Methods of experimental evaluation of lateral forces (review)]. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2017, Vol. 76, no. 1, pp. 10 – 18. DOI: http://dx.doi.org/10.21780/2223-9731-2017-76-1-10-18.
15. Ershkov O. P. Ustanovlenie koeffitsientov, uchityvayushchikh bokovoy izgib i kruchenie rel'sov [Establishing the coefficients, taking into account the lateral bending and torsion of the rail]. Trudy TsNII MPS [Proc. of the Central Research Institute of the Ministry of Railways]. Moscow, Transzheldorizdat Publ., 1955, no. 97, pp. 289 – 325.
16. Ershkov O. P. Issledovanie zhestkosti zheleznodorozhnogo puti i ee vliyanie na rabotu rel'sov v krivykh uchastkakh [Study on the rigidity of the railway track and its influence on the operation of rails in curved sections]. Trudy TsNII MPS [Proc. of the Central Research Institute of the Ministry of Railways]. Moscow, Transzheldorizdat Publ., 1963, no. 264, pp. 39 – 98.
17. Schlumpf G. Messungen mit Dehnungsmesstreifen bei den SBB. Technische Rundschau. Bern, 1955, no. 26, pp. 35 – 41.
18. Weber H. H. Zur direkten Messung der Krafte zwischen Rad und Schiene. Elektrischen Bahnen. Bеrn, 1961, no. 5, pp. 93 – 110.
19. Danilenko E. I., Frolov L. N., Romanov V. M., Grayaev A. B., Moras E. Vliyanie vertikal'noi nagruzki pri izmerenii gorizontal'nykh sil v puti [Influence of vertical load when measuring horizontal forces in the track]. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 1979, no. 1, pp. 41 – 44.
20. Timoshenko S. P. Soprotivlenie materialov [Materials resistance]. Moscow, Nauka Publ., 1965, Vol. 1, 363 p.
21. Gapanovich V. A. Voprosy vzaimodeistviya podvizhnogo sostava i infrastruktury pri tyazhelovesnom dvizhenii [Questions of the interaction of rolling stock and infrastructure under heavy traffic]. Zheleznodorzhnyy transport, 2016, no. 10, pp. 10 – 15.
22. Gorbachenko V. I. Vychislitel'naya lineinaya algebra s primerami na MATLAB [Computational linear algebra with examples on MATLAB]. St. Petersburg, BKhV-Peterburg Publ., 2011, 320 p.
Review
For citations:
Romen Yu.S., Suslov O.A., Balyaeva A.A. Determining the force of interaction in a wheel - rail system based on measuring stresses in rails neck. RUSSIAN RAILWAY SCIENCE JOURNAL. 2017;76(6):354-361. (In Russ.) https://doi.org/10.21780/2223-9731-2017-76-6-354-361
Views:
1934
.jpg)
Email this article 