Methodical issues of determination of the average heat transfer coefficient of the passenger car body
https://doi.org/10.21780/2223-9731-2019-78-6-344-350
Abstract
The article examines methodical issues of selection of heat insulation materials, their properties affecting energy efficiency, as well as methodical issues of experimental determination of heat insulation properties of the car body. This issue has become recently relevant due to the increased requirements to saving of the fuel and energy resources and to improvement of the passenger travel comfort. Domestic and international regulatory documents are analyzed from this perspective.
Contemporary materials used for heat insulation of the car body, methods of determination of the average heat transfer coefficient and requirements to such materials are examined. Review of the test results of the most widely spread passenger cars; the issue is arisen regarding necessity of putting the obtained results of experimental research in compliance with the actual operating conditions with regard to the changes of temperature, air humidity and car movement speed.
The article examines in details disadvantages of the currently used standardized method of determination of the average heat transfer coefficient. The issues affecting accuracy of determination of this parameter are underlined, which occur in the experimental research and in processing of the obtained results. Practical use of obtained results for designing of new rolling stock is examined.
Ultimately, the authors conclude that the valid domestic standardized method of determination of the average heat transfer coefficient does not take into account the number of important conditions. Examination of effect of these conditions on the results of experimental research allows the authors to make conclusion regarding necessity of review of methodical and regulatory and technical documentation for the test methods.
About the Authors
S. L. Samoshkin
Closed Joint Stock Company Scientific Agency “Tver Car-building Institute” (CJSC SA “TIV”)
Russian Federation
Russian Federation
Sergey L. Samoshkin, Dr. Sci. (Eng.), Head of the Department of Scientific and Technical Support and Development
Tver, 170003
A. O. Meyster
Closed Joint Stock Company Scientific Agency “Tver Car-building Institute” (CJSC SA “TIV”)
Russian Federation
Russian Federation
Artem O. Meyster, Adjustment and Test Engineer of Category 1
Tver, 170003
M. A. Yukhnevskiy
Closed Joint Stock Company Scientific Agency “Tver Car-building Institute” (CJSC SA “TIV”)
Russian Federation
Russian Federation
Maksim A. Yukhnevskiy, Head of the Laboratory “Fire Fighting Measures and New Materials”
Tver, 170003
References
1. Meister A. O., Yukhnevskiy M. A. Analiz sposobov snizheniya zatrat na otopleniye passazhirskogo vagona modeli 61-4447. Materials of the XII International scientific and technical conference “Rolling stock of XXI century: ideas, requirements, and projects”. Saint Petersburg, Emperor Alexander I St. Petersburg State Transport University, 2017, рp. 94−96.
2. Bartosh E. T. Energetika izotermicheskogo podvizhnogo sostava [Power engineering of refrigerator rolling stock]. Moscow, Transport Publ., 1976, 304 p.
3. GOST R 55182–2012. Vagony passazhirskiye lokomotivnoy tyagi. Obshchiye tekhnicheskiye trebovaniya. Moscow, Standartinform Publ., 2013, 28 p.
4. Meister A. O., Yukhnevskiy M. A. Opredeleniye srednego koeffitsiyenta teploperedachi kuzovov passazhirskikh vagonov. Theses of the VI scientific practical conference “Issues and prospects of the car-building industry development”. Bryansk, Bryansk State Technical University, 2014, рp. 93−95.
5. GOST 33661–2015. Ograzhdayushchiye konstruktsii pomeshcheniy zheleznodorozhnogo podvizhnogo sostava. Metody ispytaniy po opredeleniyu teplotekhnicheskikh pokazateley. Moscow, Standartinform Publ., 2016, 31 p.
6. Golubin A. A., Naumenko S. N. Deve lopment of an algorithm for determining the heat transfer coefficient of the body of an isothermal vehicle based on the results of analysis of the heat exchange processes occurring in it. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2017, Vol. 76, no. 5, рp. 306−311. https://doi.org/10.21780/2223-9731-2017-76-5-306-311.
7. Golubin A. A., Naumenko S. N. The computer program for determining the heat transfer coefficient as a tool for saving fuel and energy resources. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2018, Vol. 77, no. 1, рp. 44−48. https://doi.org/10.21780/2223-9731-2018-77-1-44-48.
8. RD 24.050.15–89. Metodika opredeleniya srednego koeffitsiyenta teploperedachi ograzhdayushchikh konstruktsiy kuzovov passazhirskikh vagonov. Utv. Ministerstvom tyazhelogo, energeticheskogo i transportnogo mashinostroyeniya SSSR 24.07.1989. Moscow, 1989, 20 p.
9. Naumenko S. N., Teimurazov N. S., Golubin A. A. Tochnost’ opredeleniya koeffitsiyenta teploperedachi. Zheleznodorozhnyy transport na sovremennom etape: zadachi i puti ikh reshe niya. Sb. tr. Ed. by A. E. Semechkin. Moscow, Intext Publ., 2008, рp. 76−78.
10. Naumenko S. N., Teimurazov N. S., Golubin A. A. Otsenka tochnosti opredeleniya v depovskikh usloviyakh koeffitsiyenta teploperedachi kuzova izotermicheskogo vagona. Coll. of reports of participants of the combined scientific session of RAS: Energy saving and protection of environment at the heat engineering facilities of railway transport, industry and municipal services. Moscow, Russian University of Transport, 2008, рp. 189−192.
11. Golubin A. A., Belova N. V., Naumenko S. N. Effect of measurement errors in determining the heat transfer coefficient of the enclosing structures of an isothermal car. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2019, Vol. 78, no. 2, рp. 100−104. https://doi.org/10.21780/2223-9731-2019-78-2-100-104.
12. Obukhov I. V. Sluchaynyye pogreshnosti izmereniy [Random errors of measurements]. Moscow, URSS, 2017, 80 p.
13. Anisimov P. S. Ispytaniya vagonov [Car tests]. Moscow, Marshrut Publ., 2004, 197 p.
14. Sokolov M. M., Varava V. I., Levit G. M. Izmereniya i kontrol’ pri remonte i ekspluatatsii vagonov. Moscow, Transport Publ., 1991, 158 p.
15. GOST 15150–69. Mashiny, pribory i drugiye tekhnicheskiye izdeliya. Ispolneniya dlya razlichnykh klimaticheskikh rayonov. Kategorii, usloviya ekspluatatsii, khraneniya i transportirovaniya v chasti vozdeystviya klimaticheskikh faktorov vneshney sredy. Moscow, Publishing House of standards, 1970, 53 p.
Review
For citations:
Samoshkin S.L., Meyster A.O., Yukhnevskiy M.A. Methodical issues of determination of the average heat transfer coefficient of the passenger car body. RUSSIAN RAILWAY SCIENCE JOURNAL. 2019;78(6):344-350. (In Russ.) https://doi.org/10.21780/2223-9731-2019-78-6-344-350
Views:
846
.jpg)
Email this article 