Practical use of on-board fuel metering systems of diesel locomotives
https://doi.org/10.21780/2223-9731-2022-81-4-370-382
Abstract
Introduction. On-board fuel metering systems for diesel locomotives created by different manufacturers differ both in the composition of the sensors used and in the software for processing the registration data. This indicates that the pursuit of better efficiency for these systems is still ongoing and is an urgent problem.
Materials and methods. The article discusses the problems of determining the fuel consumption according to the data of on-board fuel metering systems for diesel locomotives, associated with various methods for determining the moments of measuring the fuel amount in the tank. The possibility of estimating the influence of the number of position switches of the locomotive throttle on the indicators of absolute and specific fuel consumption has been studied.
Results. In the absence of distance and speed sensors in the on-board system, it is proposed to determine the moments of measurement of the fuel amount based on the analysis of changes in the signals of the fuel level sensors over time. The authors present an example of the practical implementation of this solution. The results of on-board systems data processing are also presented, showing that the effect of the spread in the number of throttle position switches observed in ordinary operation of diesel shunter on fuel consumption is comparable to the error in determining this value according to the on-board systems data. The implementation of algorithms in specialised software designed to process data from onboard systems that allow identifying the indicated influence is relevant only for cases of extreme (by an order of magnitude) difference in the number of switching throttle positions in work shifts.
Discussion and conclusion. The efficiency of the practical use of information from the on-board systems for metering fuel consumption of a diesel locomotive is largely determined by the quality of specialised software. When developing and improving software, it is recommended to use the approaches discussed in the article.
About the Author
K. P. PopovRussian Federation
Kirill M. POPOV, Cand. of Sci. (Engineering), Leading Researcher, Digital Models
of Transportation and Energy Saving Technologies Scientific Centre
129626, Moscow, 10, 3rd Mytishchinskaya St.
References
1. Chikirkin O. V. Sovershenstvovat' sistemu ucheta toplivno-energeticheskikh resursov [Improvement of the metering system for fuel and energy resources]. Lokomotiv = Locomotive. 2018;(8):2-5. (In Russ.).
2. Golovash A. N., Bocharov V. M. Bortovye kompleksy dlya lokomotivov [On-board systems for locomotives]. Zheleznodorozhnyy transport = Railway transport. 2004;(10):76-77. (In Russ.).
3. Grishchenko A. V., Grachev V. V., Lavskiy V. G. et al. Sovremennye informatsionnye tekhnologii dlya teplovozov [Modern information technologies for diesel locomotives]. Lokomotiv = Locomotive. 2007;(4):18-24. (In Russ.).
4. Golovash A. N., Bocharov V. M., Kuznetsov S. M. Effektivnost' ispol'zovaniya bortovykh sistem ucheta topliva na lokomotivakh [Efficiency of using on-board fuel metering systems on locomotives]. Lokomotiv = Locomotive. 2008;(11):21-22. (In Russ.).
5. Muginshteyn L. A., Molchanov A. I., Popov K. M. Sovershenstvovanie sistemy ucheta i kontrolya raskhoda topliva manevrovykh teplovozov [Improving the system of metering and control of fuel consumption of shunting diesel locomotives]. Vestnik Nauchno-issledovatel'skogo instituta zheleznodorozhnogo transporta (Vestnik VNIIZhT) = Russian Railway Scientific Journal. 2010;(1):8-18. (In Russ.).
6. Igin V. N., Zakhvatov A. V., Karyanin V. I. Avtomatizatsiya kontrolya raskhoda topliva [Automation of fuel consumption control]. Lokomotiv = Locomotive. 2015;(2):13-17. (In Russ.).
7. Tekhnicheskie trebovaniya k sistemam registratsii i analiza parametrov raboty teplovoza i ucheta dizel'nogo topliva [Technical requirements for systems for recording and analyzing the parameters of the operation of a diesel locomotive and metering of diesel fuel] (Electronic resource). Approved by Senior Vice President of Russian Railways V. A. Gapanovich dated March 7, 2014, No. 125. Access from ASPIZhT. (In Russ.).
8. Grachev V. V., Bazilevskiy F. Yu., Cheremisinov P. A., Popov A. V. Otsenka tochnosti izmereniya kolichestva topliva v bake teplovoza gidrostaticheskim izmeritelem [Assessment of the accuracy of measuring the amount of fuel in the tank of a diesel locomotive by a hydrostatic meter]. Vestnik Nauchno-issledovatel'skogo instituta zheleznodorozhnogo transporta (Vestnik VNIIZhT) = Russian Railway Scientific Journal. 2008;(5):29-32. (In Russ.).
9. Naumenko S. N., Godnev A. G. O dostovernosti ucheta dizel'nogo topliva pri ekipirovke lokomotivov [On the reliability of accounting for diesel fuel when equipping locomotives]. Zheleznodorozhnyy transport = Railway transport. 2011;(2):49-51. (In Russ.).
10. Fedotov M. V., Koshcheev S. N., Bychkova E. A., Grachev V. V. Vliyanie formy baka i uklona puti na tochnost' izmereniya kolichestva topliva v bake teplovozov [Influence of the tank shape and track slope on the accuracy of measuring the amount of fuel in the tank of diesel locomotives]. Vestnik Nauchno-issledovatel'skogo i konstruktorskotekhnologicheskogo instituta podvizhnogo sostava (Vestnik VNIKTI) = Bulletin of the Research and Design and Technology Institute of Rolling Stock. 2015;(97):81-87. (In Russ.).
11. Grachev V. V., Grishchenko A. V., Bazilevskiy F. Yu. O dostovernosti pryamykh sposobov operativnogo kontrolya energoeffektivnosti teplovozov v ekspluatatsii [On the reliability of direct methods of operational control of the energy efficiency of diesel locomotives in operation]. Vestnik instituta problem estestvennykh monopoliy: Tekhnika zheleznykh dorog = Bulletin of the Institute for Problems of Natural Monopolies: Railway Engineering. 2018;(2):40-48. (In Russ.).
12. Kostenko V. V., Sugorovskiy A. V., Khomich D. I. et al. Dopolnitel'nye pokazateli ispol'zovaniya manevrovykh lokomotivov [Additional indicators of the use of shunting locomotives]. Transport Rossiyskoy Federatsii = Transport of the Russian Federation. 2018;(2):33-37. (In Russ.).
13. Anisimov A. S., Minakov V. A., Noskov V. O. Otsenka vliyaniya raboty teplovoza na kholostom khodu na iznos detaley dizelya [Evaluation of the impact of locomotive idling on the wear of diesel parts]. Vestnik Ural'skogo gosudarstvennogo universiteta putey soobshcheniya = Herald of the Ural State University of Railway Transport. 2022;(1):40-45. https://doi.org/10.20291/2079-0392-2022-1-40-45. (In Russ.).
14. Taruta V. F., Chulkov A. V., Milyutina L. V. Tekhnologiya kontrolya urovnya moshchnosti dlya nastroyki dizel'-generatornoy ustanovki manevrovogo teplovoza s uchetom usloviy ekspluatatsii [Technology for controlling the power level for setting up a diesel generator set of a shunting diesel locomotive, taking into account operating conditions]. Izvestiya Transsiba = Journal of Transsib Railway Studies. 2018;(1):109-117. (In Russ.).
15. Svechnikov A. A. Snizhenie udel'nogo raskhoda topliva manevrovymi teplovozami putem optimizatsii parametrov dizel'noy ustanovki [Reducing the specific fuel consumption of shunting diesel locomotives by optimizing the parameters of a diesel plant]. Vestnik transporta Povolzh'ya = Bulletin of Transport of the Volga Region. 2021;(3):68-73. (In Russ.).
16. Lyamin V. A., Shkarin V. N. Otsenka tekhnicheskogo urovnya manevrovogo teplovoza [Assessment of the technical level of a shunting diesel locomotive]. Sovershenstvovanie manevrovykh teplovozov, ikh remonta i ekspluatatsii [Improvement of shunting diesel locomotives, their repair and operation]. Procs. of All-Union Railway Research Institute. Moscow: Transport Publ.; 1985. P. 68–72. (In Russ.).
17. Sekerin E. V. Effektivnyy put' ekonomii topliva na manevrovoy rabote [An effective way to save fuel on shunting work]. Elektricheskaya i teplovoznaya tyaga = Electric and diesel traction. 1971;(7):18. (In Russ.).
18. Beloglazov A. K., Molchanov V. V., Noskov V. O., Chulkov A. V. Issledovanie i analiz usloviy ekspluatatsii i raskhoda topliva teplovozami v manevrovom dvizhenii [Research and analysis of operating conditions and fuel consumption of diesel locomotives in shunting]. Ekspluatatsionnaya nadezhnost' lokomotivnogo parka i povyshenie effektivnosti tyagi poezdov [Operational reliability of the locomotive fleet and improving the efficiency of train traction]. Procs. of 3rd All-Russian sci.-tech. conf. with international participation (Omsk, November 10–11, 2016). Omsk: OmGUPS Publ.; 2016. P. 48–52. (In Russ.).
19. Muginshteyn L. A., Molchanov A. I., Povarkov I. L., Popov K. M. Patent No. 2266529 Russian Federation, MPK G01M 15/00, G01F 9/00. Sposob kontrolya tekhnicheskogo sostoyaniya silovoy ustanovki transportnogo sredstva [The method of monitoring the technical condition of the power plant of the vehicle]: No. 2004102584/28: appl. 29.01.2004: publ. 20.12.2005. 12 p. (In Russ.).
20. Grachev V. V., Kurilkin D. N., Kim S. I., Sergeev S. V. Vliyanie perekhodnykh protsessov dizel'-generatornoy ustanovki teplovoza 2TE116U na ego ekspluatatsionnye pokazateli [Influence of transient processes of the diesel generator set of the diesel locomotive 2TE116U on its performance]. Lokomotivy. XXI vek [Locomotives. XXI century]. Procs. of the Int. sci.-tech. conf. dedicated to the 110th Anniversary of the birth of Dr. of Engineering Sciences, Professor E. Ya. Gakkel (St. Petersburg, October 15–16, 2013). St. Petersburg State University of Communications, Russian Railways. St. Petersburg: PGUPS Publ.; 2013. P. 146–147. (In Russ.).
21. Shvaynshteyn B. S., Mayorov E. G., Shalaev S. S. Teplovozy ChME3 i ChME2 [Diesel locomotives ChME3 and ChME2]. Moscow: Transport Publ.; 1975. 376 p. (In Russ.).
22. Babkov Yu. V., Belova E. E., Klimenko Yu. I. et al. Patent No. 2591556 Russian Federation, MPK G01M 17/08, B61C 5/00. Sposob kontrolya tekhnicheskogo sostoyaniya silovoy ustanovki zheleznodorozhnogo transportnogo sredstva [Method for monitoring the technical condition of the power plant of a railway vehicle]: No. 2015115795/11: appl. 28.04.2015: publ. 20.07.2016. 11 p. (In Russ.).
Review
For citations:
Popov K.P. Practical use of on-board fuel metering systems of diesel locomotives. RUSSIAN RAILWAY SCIENCE JOURNAL. 2022;81(4):370-382. (In Russ.) https://doi.org/10.21780/2223-9731-2022-81-4-370-382