New method for control of fuel injection initiation and fuel combustion in diesel locomotive engines
https://doi.org/10.21780/2223-9731-2019-78-4-233-240
Abstract
Adequate regulation of diesel engine fuel equipment is an important factor affecting the economic and ecological indicators of diesel engine and its reliability. The fuel injection advance angle deviates from the best value during operation for several reasons, requiring timely control and regulation of the parameter. This issue is crucial for diesel engines with individual high-pressure pumps like the diesel locomotive engines. This study presents a new method for indirect determination of the fuel injection advance angle based on analysis of the pressure fi rst-order derivative signal — pressure change rate. This method eliminates the need for additional measurements like the crankshaft rotation angle or piston position, and therefore, exhibits potential for the development of easy and reliable devices for online diagnostics. The study also briefl y analyzes control methods for the fuel injection advance angle used in operating diesel-electric locomotives in Russia. The results of theoretical research performed through mathematical modeling for the locomotive diesel engine 1А-5D49 is also examined. A dimensionless criterion is proposed based on results calculated from the experiment, which is determined by the value of the pressure change rate signal at representative points allowing calculation of the fuel injection advance angle using simple linear dependence. Verifi cation of the proposed method demonstrates good agreement of the results with existing methods.
About the Authors
A. Yu. Kon’kov
Far Eastern State Transport University (FESTU)
Russian Federation
Russian Federation
Aleksey Yu. Kon’kov, Dr. Sci. (Eng.), Professor of the Department of the Railway Transport
I. D. Kon’kova
Far Eastern State Transport University (FESTU)
Russian Federation
Russian Federation
Irina D. Kon’kova, Senior Lecturer of the Department of the Railway Transport
References
1. Khomich A. Z. Toplivnaya effektivnost’ i vspomogatel’nye rezhimy teplovoznykh dizeley [Heat effi ciency and auxiliary modes of the diesel-electric locomotive diesels]. Moscow, Transport, 1987, 271 p.
2. Smirnov V. A., Talyzin A. S. Energosberezhenie pri remonte i tekhnicheskom obsluzhivanii lokomotivov [Energy savings by locomotive repair and preventive maintenance]. Izvestiya Transsiba [News of Transsib], 2011, no. 4(8), рр. 41–49.
3. Sirotenko I. V., Gogrichiani G. V. Problemy povrezhdaemosti silovykh i teplonapryazhennykh uzlov teplovoznykh dizeley. Ana liticheskiy obzor [Damaging problems of power and heat-stressed assemblies of locomotive diesels. Analytical review]. Vestnik VNIIZhT [Vestnik of the Railway Research Institute], 2017, Vol. 76, no. 2, рр. 101–109. DOI: 10.21780/2223-9731-2017-76-2- 101-109.
4. Fedotov G. B., Levin G. I. Toplivnye sistemy teplovoznykh dizeley: remont, ispytaniya, sovershenstvovanie [Fuel systems of the diesel-electric locomotive diesels. Repair, tests, improvement]. Moscow, Transport, 1983, 192 p.
5. Makushev Yu. P., Volkova L. Yu. Datchiki dlya issledovaniya i diagnostirovaniya protsessa podachi topliva v sistemakh pitaniya dizeley [Sensors for study and diagnosis of fuel supply process in diesel power systems]. Omskiy nauchnyy vestnik [Omsk Scientifi c Bulletin], 2016, no. 3(147), рр. 28–32.
6. Zhdanovskiy N. S., Nikolaenko A. V., Ulitovskiy B. A., Alliluev V. A. Diagnostika avtotraktornykh dvigateley [Diagnostics of the motor-transport engones]. Leningrad, Kolos, 1977, 264 p.
7. Kon’kov A.Yu., Lashko V. A. Diagnostirovanie dizelya na osnove identifi katsii rabochikh protsessov [Diagnostics of diesel based on identifi cation of the work processes]. Vladivostok, Dalnauka, 2014, 365 p.
8. Dvigateli vnutrennego sgoraniya: Teoriya porshnevykh i kombinirovannykh dvigateley [Internal combustion engines: Theory of reciprocating and compound engines] / D. N. Vyrubov [et al.]. Moscow, Machine building, 1983, 375 p.
9. Kavtaradze R. Z. Teoriya porshnevykh dvigateley. Spetsial’nye glavy [Theory of reciprocating engines. Special chapters]. M.: Izd-vo MGTU im. N. E. Baumana [Moscow: Publishing house of Bauman Moscow State Technical University], 2008, 720 p.
10. Solov’yev A. V. Sistemy monitoringa sudovykh dizeley v ekspluatatsii [Systems of monitoring marine diesel engines in operation]. Vestnik Astrakhanskogo gosudarstvennogo tekhnicheskogo universiteta. Seriya: Morskaya tekhnika i tekhnologiya [Bulletin of Astrakhan State Technical University], 2018, no. 1, рр. 87–92. DOI: 10.24143/2073-1574-2018-1-87-92.
11. Balabin V. N., Kakotkin V. Z., Lobanov I. I. Ekspress-diagnostika teplovoznykh dizeley [Promising express troubleshooting of locomotive diesel engines]. Mir transporta [World of transport and transportation], 2012, Vol. 10, no. 3(41), рр. 38–43.
12. Vasin P. A. Dlya diagnostiki teplovoza-kompleks “Magistral” [Complex “Magistral” for diesel-electric locomotive diagnostics]. Lokomotiv [Locomotive], 2001, no. 7, рр. 27–31.
13. Bueno A. V., Velásquez J. A., Milanez L. F. A new engine indicating measurement procedure for combustion heat release analysis. Applied Thermal Engineering, 2009, Vol. 29, no. 8–9, рр. 1657–1675.
14. Bueno A. V., Velásquez J. A., Milanez L. F. Internal combustion engine indicating measurements. In: Applied Measurement Systems. Prof. Zahurul Haq (Ed.), 2012. Available from: https://pdfs. semanticscholar.org/1e41/2925077f37d272ab5a3228e50abf36aad 10a.pdf (retrieved on 21.05.2019).
15. Kon’kov A. Yu., Lashko V. A. Sredstva i metod diagnosti rovaniya dizeley po indikatornoy diagramme rabochego protsessa [Means and methods of diesel diagnostics by the indicator diagram of the work process]. Khabarovsk: Izd-vo DVGUPS [Khabarovsk: publishing house of Far Eastern State Transport University], 2007, 147 p.
16. Kon’kova I. D., Davydov Yu. A., Kon’kov A. Yu. Matematicheskaya model’ motornogo tsikla dizelya i ee programmnaya realizatsiya v srede Simulink Matlab [Mathematical model of the diesel motor cycle and its program implementation in SimulinkMatlab environment]. Vestnik transporta Povolzh’ya [Bulletin of transport of the Volga region], 2018, no. 5(71), рр. 73–81.
17. Kuleshov A. S., Kozlov A. V., Fadeev Yu. M. Programma DIZEL’’-RK: modelirovanie i optimizatsiya rabochikh protsessov DVS / DVIGATEL’’-2010: Materialy mezhdunarodnoy konferentsii, posvyashchennoy 180-letiyu MGTU im. N.E. Baumana [Program DIESEL-RK: Modeing and optimization of the work processes of ICE / Collection of scientifi c works of the international conference Engine-2010], 16.10.2010, Moscow, рр. 287–292.
18. Lashko V. A., Kon’kov A. Yu. Poluchenie indikatornoy diagrammy pri asinkhronnom izmerenii signala davleniya [Indicator test based on asynchronous pressure measurement]. Dvigatelestroenie, 2007, no. 4(230), рр. 33–37.
19. Kon’kov A. Yu., Trunov A. I., Kon’kova I. D., Davydov Yu. A. Diagnostirovanie neplotnosti tsilindra dizelya po rezul’tatam izmereniya skorosti izmeneniya vnutritsilindrovogo davleniya [Diagnosing the leakage of a diesel engine cylinder according to the results of measuring the in-cylinder pressure rate oi change]. Vestnik Tikhookeanskogo gosudarstvennogo universiteta [Bulletin of Pacifi c national university], 2018, no. 4(51), рр. 9–16.
20. Kon’kova I. D., Davydov Yu. A., Kon’kov A. Yu. Novyy sposob diagnostirovaniya neplotnosti tsilindra dizelya s primeneniem p’ezoelektricheskogo datchika davleniya / Sbornik materialov VI Mezhdunarodnoy nauch.-tekhn. konf. “Lokomotivy. Elektricheskiy transport. XXI vek” [New method of diagnostics of the diesel cylinder leakiness using piezoelectric pressure sensor / Collection of material of the VI International scientifi c-practical conference Locomotives. Electric transport. XXI century]. SPb., FGBOU VO PGUPS [Saint Petersburg, Petersburg State Transport University], 2018, рр. 78–84.
Review
For citations:
Kon’kov A.Yu., Kon’kova I.D. New method for control of fuel injection initiation and fuel combustion in diesel locomotive engines. RUSSIAN RAILWAY SCIENCE JOURNAL. 2019;78(4):233-240. (In Russ.) https://doi.org/10.21780/2223-9731-2019-78-4-233-240
Views:
764
.jpg)
Email this article 